You must NEVER jack anywhere else on the chassis rails. Jan 5, 2008. These Jack points are good for all 2001- #dodgecaravan #jackpointlocation #howtoIn this video, I go through the jack point locations on a 2005 Dodge Caravan. The kojack set includes a 3-tier hydraulic bottle jack, 2 x chassis brackets with integral spirit levels and all necessary fittings and fixings. Do not use the corner steadies as jacks under any circumstance as you can endanger yourself, and cause serious damage to the corner steadies and their mounts. There are three points of contact with the ground, the wheels on either side of the axle and the tow hitch/jockey wheel. This heavy-duty scissor caravan jacking system is for single axel caravans and lifts loads up to 1500kg. Last is with use of the side lift jack. caravan jack Guide guides how to Safety Tips. No problem with the Kojack, most caravans have lifting points welded into the chassis, and the Kojack comes with multiple jacking point adapters to suit your van. I'd think if the manual does not prohibit these points to use with the floor jack then you should be ok. Just looking to change to winter tires myself. Jack Weight: 4.7kg. If you don't, depending on ground and weather conditions, the caravan could tip over. There are a number of locations under the van where it will still be safe to jack it up, if you go further under the vehicle to reach the subframe near the vans suspension ahead of the rear wheel, or near the drive train frame behind the front wheel, avoiding any lines or cables in either case. This is only a stop-gap measure. All caravans fitted with an Al-Ko chassis manufactured after 1991 will Underbody Rusting Out Where Scissor Jack Goes In Front Of Car. If you know the correct, safe procedure, then the other causes of jacking accidents are clearly the jack: (a) Not being completely suitable for that particular caravan, and; (b) Not having its top positively-located so as to prevent it sliding in any horizontal direction. Diagram 1 Normal Condition. If you don't, depending on ground and weather conditions, the caravan could tip over. Total Weight: 6.1kg. SEcond is under the reinforced web where the axle tube attaches to the chassis. This should give sufficient height to insert jack stand. If its an Alko chassis you can buy a side lift jack which comes with two jacking brackets that bolt into pre-drilled holes. #3. Jack Width: 140mm. For more information click here. Therefore J x LJ must equal (or exceed) 2000kg.m. To provide stability and safety you should only consider jacking up the caravan when its attached to your car. Try using your floor jack, and a block of wood, and put it under the jacking point. Advertisement. Nov 14th, 2013 3:15 pm. Jacking points on a Coachman twin axle caravan Jacking points on a Coachman twin axle caravan Briang replied on 04/05/2021 14:43 To get these fitted the jacking points had to be removed along with the spare wheel carrier. However, there are jacking brackets you can get for the AL-KO caravan chassis, either installed by your service centre or DIY. This video from Practical Caravan shows how the AL-KO jacking plates are fitted to a caravan. I think its pretty ridiculous that these brackets arent fitted as standard on every AL-KO chassis. Once you have located the jacking points, it is also important Use the owner's manual to find the Grand Caravan jacking points and this video to see additional jacking tips to help minimize the risk of injury. How To Jack Up A Caravan Safely & Securely - Jacks, Hints & Tips To provide stability and safety you should only consider jacking up the caravan when its attached to your car. 5th Gen 08 Jacking Points 08 Grand Caravan Dodgeforum Com. I will be using a floor jack and it's usually not recommended to jack it up by the pinch weld as shown in the owner's manual. If you don't, depending on ground and weather conditions, the caravan could tip over. Jack Compressed Height: 170mm. Reply with quote. The relationship between a jacks Load (lifting force) and its Travel, is a basic physics topic of Moments which is Force X Distance.. With the Ball as the pivot, it is a balance or a compromise for any given effective Load (M) times its Distance (LM) from the pivot and the jacks available Force (J) times its Distance (LJ) from How do I jack up the caravan to fit the rear Alco lock. Thanks! Need to change a tyre? Most Dodge jack kits include the jack, a jack handle and a lug nut wrench. These points will be detailed in the caravans handbook. I se what you're saying. Nov 14, 2016. Without the slot that is on the top of the scissor jack, side forces on a vehicle being held by a floor jack, hydraulic lift, or jack stand will eventually bend and even break the welded seam that IS Anyone know how. This jack also doubles as a drawbar stand and jockey wheel. First is directly under the axle tube where it meets the chassis rail. WARNING: THE HOISTING AND JACK LIFTING POINTS PROVIDED ARE FOR A COMPLETE VEHICLE. Thanks for the response. Or, wrap the jack stand in a blanket, and drive it off the stand. I like bottle jacks, they are compact and relatively lightweight compared to say a trolley jack for instance. This Kojack caravan bottle jack is 4.7kg, thats still not exactly lightweight. Therefore if you were to take one with you on your travels you would need to consider its impact on your caravan payload. L-Bracket Weight: 0.7kg. If LJ is 3m, J must exceed 667kg. Designed and rated at 4t, this caravan jack can lift from your caravans chassis or towball if required. In several places people recommend the jack points that are identified in the owner's manual, but those are not where you would want to lift with a jack or a hydraulic car lift. The manufacturer claims they are heavy duty construction with a 2,000 lb capacity. Jack Depth: 130mm. In the photo a caravan-specific Trail A Mate hydraulic jack is connected to a manufacturer fitted jacking point. Raise slowly, and make sure you don't buckle the rocker panel. There are three points of contact with the ground, the wheels on either side of the axle and the tow hitch/jockey wheel. The Kojack uses a similar principal and its a scissor jack. The Trail-A- Mate Service kits are available from Seatra International Pty Ltd, 233 Shepherds Hill Road, Eden Hills SA 5050. #2. There are three points of contact with the ground, the wheels on either side of the axle and the tow hitch/jockey wheel. There are three points of contact with the ground, the wheels on either side of the axle and the tow hitch/jockey wheel. Caravans have recommended lifting points and these should be the only areas where you place the jack. L-Bracket Height: 155mm. my Alko care and maintainence instructions states that the corner steadies should never be used to jack up the caravan---fair enough most of us are aware of that. To raise the vehicle so as to insert jack stands, place a floor jack under the front suspension lower member close to the wheel and lift. 2014 Chrysler Town And Country Jack Points. Put two wedges of wood in front of your front wheels and two behind them. Ph (08) 8278 5107 or email [email protected]. If you purchase a Trail-A-Mate it comes with a pair of those jacking points so you can have them welded to most vans (you can not use them on European vans or Jaycos without strengthening the chassis.) I was never hesitant using factory jacking points with the floor jack. In the rear use the floor jack on a bracket close to each wheel to lift. There are other Hydraulic Camper Jacks available. Single axle caravan jacking system; Suitable for most AL-KO caravan chassis from 1992 onward. Jack Extended Height: 390mm. The trolley jack must be able to move forward during the lift and backwards during the drop. Jacks that provide a vertical lift are much safer for use on caravans as the jacking surface under the caravan is unpredictable. To provide stability and safety you should only consider jacking up the caravan when its attached to your car. Any help would be appreciated . Put the jack under the back frame of the car and lift it up until the wheels are off the ground. Reply. Jack Up Dodge Caravan Remove Tire Change A Tire Episode 4 Of 6. 3 Answers. If LJ is 4m, J must exceed 500kg. And now you know how to safely jack your caravan. #3. If it is prevented from doing so the jack can slip off the jacking point or even bend or break it. If you have a flat tire in your Dodge Grand Caravan, please see our how do I fix a flat tire video. WHEN THE ENGINE OR REAR SUSPENSION IS REMOVED FROM A VEHICLE, THE CENTER OF GRAVITY IS ALTERED MAKING SOME On caravans that are built on the lightweight ALKO chassis, jacking points do not exist unless you purchase an add-on kit. Many vans are supplied with the lifting point for a Trail-A-Mate jack welded to the bottom of the cross member immediately behind the rear of the wheel arch. However, what many caravanners are not aware of is there are only certain points on a caravan chassis where it is safe to use that jack. There are only certain points on a caravan you should jack from: Image Amazon.co.uk Disclaimer: Hey! If you don't, depending on ground and weather conditions, the caravan could tip over. Comes complete with 2x chassis brackets, fixtures and fittings, and a matching storage case. First, locate the mounting points on the caravan chassis. Slide the two jack stands underneath the car right under the axles, one next to each wheel. Hi, under the axle point is safest as the chassis is not so strong. 0. Use the points labeled #2 as the area to support with jack stands. Sliding Door Won T Open Manually 2005 Dodge Grand Caravan In. There is an Australian consumer product safety standard for vehicle jacks, referencing the Australian/New Zealand Standard AS/NZS 2693:1993 Vehicle Jacks or AS/NZS 2693:2003 Vehicle Jacks (with The jacking points mentioned in the manual are clearly for a scissor jack but the sill flange was bent a bit the last time I took it to be changed. To provide stability and safety you should only consider jacking up the caravan when its attached to your car. There are only three places where the van can be jacked safely. I just don't understand why Jayco, and other caravan makers for that matter, insist on putting those wind-up scissor jacks in as emergency equipment when they are not only incapable of lifting the wheel clear of the ground, but are also dangerous. Park the Dodge on a flat, level surface and engage the parking brake. They consist of a pair of vertical holes just forward of the spare-wheel carrier and to the rear of the wheels when viewed from the side. All features. Posted: Tue Feb 22, 2011 9:42 pm Post subject: jacking up an ALKO chassis.